Kia Cee'd: Rear Wiper/Washer / Rear Wiper Motor Repair procedures

Kia Cee'd JD Service Manual / Body Electrical System / Rear Wiper/Washer / Rear Wiper Motor Repair procedures

Inspection

Rear Wiper Motor

1.	Remove the 4P connector from the rear wiper motor.

2.	Connect battery positive (+) and negative (-) cables to terminals 3 and 4 respectively.

Check that the motor operates normally. Replace the motor if it operates abnormally.

No.	Description
1	Battery (+)
2	Parking
3	Wiper motor input (+)
4	Ground

Automatic Stop Operation Check

1.	Operate the motor at low speed using the stalk control.

2.	Stop the motor operation anywhere except at the off position by disconnecting terminal 3.

3.	Connect terminals 2 and 3.

4.	Connect the positive (+) lead from the battery to terminal 1 and the negative (-) lead to terminal 4.

5.	Check that the motor stops running at the off position.

Removal

1.	Detach the rear wiper cap (A).

2.	Remove the rear wiper arm & blade (A) after removing rear wiper nut (B).

3.	Open the tailgate then remove the tailgate trim. (Refer to Body - "Tailgate Trim")

4.	Disconnect the rear wiper motor connector (B) then remove the rear wiper motor (A) after loosening bolts (3EA).

Installation

Install the rear wiper motor assembly and the grommet.

Tightening torque Bolt :

6.9~9.8 N.m (0.7~1.0 kgf.m, 5.0~7.2 lbf.ft)

2.	Install the tailgate trim.

3.	Set the rear wiper blade and to the lowest defogger heat line and tailgate glass.

Install the rear wiper cap and rear wiper nut.

Tightening torque Nut :

3.9~6.9 N.m (0.4~0.7 kgf.m, 2.9~5.0 lbf.ft)

Components and components location

Component Location 1. Head cap 2. Rear wiper arm nut 3. Rear wiper arm & blade 4. Grommat 5. Rear wiper motor 6. Rear wiper motor bolt ...

Rear Washer Switch Repair procedures

Inspection Check for continuity between the terminals while operating the wiper and washer switch. If it is not normal condition, replace wiper and wiper switch. Rear W ...

Other information:

Kia Cee'd JD Service Manual: Rear Back Armrest Repair procedures
Replacement [5Door, Waggon only] • Put on gloves to protect your hands. ...

Kia Cee'd JD Owners Manual: Power outlet
■ Front • Type A ■ Front • Type B ■ Rear • Type A ■ Rear • Type B The power outlet is designed to provide power for mobile telephones or other devices designed to operate with vehicle electrical systems. The devices should draw less than 10 amps with the engine ru ...