Kia Cee'd: General Information / Troubleshooting
| Troubleshooting |
|
Symptom |
Suspect Area |
Remedy (Refer to page) |
|
Water leaks from panoramaroof |
Deteriorated roof lid weatherstrip |
Replace |
|
Excessive roof lid-to-body clearance and improperly fitted weatherstrip
|
Adjust |
|
|
Wind noise around panoramaroof |
Loose or deformed deflector, gaps in body work |
Retighten adjust or replace |
|
Noise heard when opening/ closing panoramaroof |
Foreign particles lodged in guide rail |
Check drive cable and guide rails for foreign particles |
|
Loose guide rails and lid |
Retighten |
|
|
Motor runs but sunroof does not move or moves only partially |
Foreign particles lodged in guide rail |
Adjust or replace |
|
Incorrect engagement of motor pinion with drive cable |
||
|
Decrease in motor`s clutch slipping force |
||
|
Increased sunroof sliding resistance or interference of sunroof with drive
cables, weatherstrip, etc. due tomal adjustment of sunroof |
||
|
Noise in motor (clutch slipping noise from motor when sunroof is fully opened
or closed is not an unusual noise |
Incorrect engagement of motor pinion with drive cable |
Check pinion installation and |
|
Re-tighten motor |
||
|
Worn out or damaged motor pinion bearing |
Replace motor assembly |
|
|
Worn out or deformed drive cable |
Replace |
|
|
Door glass fails to operate up and down |
Incorrect window glass installation |
Adjust position |
|
Damaged or faulty regulator arm or regulator |
Correct or replace |
|
|
Door does not open or close completely |
Incorrect door installation |
Adjust position |
|
Defective door check assembly |
Correct or replace |
|
|
Door hinge requires grease |
Apply grease |
|
|
Hood does not open or close completely |
Striker and latch not properly aligned |
Adjust |
|
Incorrectly installed hood |
Adjust |
|
|
Incorrect hood bumper height |
Adjust |
|
|
Water leak through windshield end rear window |
Defective seal |
Fill with sealant |
|
Defective flange |
Correct |
Special service tools
Special Service Tools
Tool (Number and name)
Illustration
Use
09861-31100
Sealany cut-out tool
...
Fender
...
Other information:
Kia Cee'd JD Service Manual: Variable Intake Solenoid (VIS) Valve Specifications
Specification
Item
Specification
Coil resistance (Ω)
30.0 ~ 35.0 [20°C(68°F)]
...
Kia Cee'd JD Service Manual: Clutch Pedal Components and components location
Components
1. Master cylinder
2. Ignition lock switch
3. Clutch switch
4. Pedal pad
...